drdiy

Humidifier Cleaning / Getting More Heat to a Second Floor

In Uncategorized on January 15, 2014 at 11:44 am

Q:

Every winter, in an effort to clean my humidifier (AutoFlo), which is attached to my furnace, I encounter a lot of white mineral deposits. This is very difficult to clean, especially the fan portion. Are these deposits dangerous in case they get circulated in the air? What is the usual life of these humidifiers? Perhaps I need a new one. Any suggestions?

A:

You can purchase any one of several humidifier cleaners available at hardware and home centers.

 

All the ones I’ve used contain either hydrochloric acid or phosphoric acid as their main ingredient to cut through and remove the mineral deposits.

Obviously, you should follow the manufacturer’s owner’s guide for cleaning yours or any humidifier. In your case, turn off the water and the humidistat. Open the unit by removing the two screws on the front. You can then lift out the drum and cylinder. If the media pad is heavily corroded with minerals, discard and replace it with a new foam pad. The plastic drum, fan and float assembly can be cleaned with an old 1 to 2-inch paintbrush or plastic brush. The cleaning should be done while you wear a long sleeved shirt, rubber gloves and eye protection. Pour about 2 capfuls of whatever it says on the brand you use in a plastic bucket or laundry tub along with the prescribed amount of warm water (i.e.: 2 capfuls per 1/2 gallon). Allow the solution to work its magic and when your humidifier and parts are clean, rinse them thoroughly. Dispose of the cleaning solution by carefully pouring it down the toilet.

Depending on the hardness of your water, most people can get away with this type of cleaning at the end of the heating season when they turn off the humidifier.

If your water is hard and you get a lot of lime and mineral accumulations, consider adding water treatment products periodically to the inside of your humidifier. They help reduce the lime and scale build-up in the unit.

By the way, if you don’t turn off and clean your humidistat at the end of the heating season you’re looking for trouble.

First, if you have air conditioning, by leaving the humidifier on, you are reducing the efficiency of the air conditioner’s dehumidification. Second, if you don’t turn it off and clean it, the unit will become corroded and useless.

Finally, if neglected, the stagnant water in the reservoir turns into pond scum that is loaded with bacteria that could lead to Legionnaire’s disease.

So you see, it’s important to clean and maintain your humidifier periodically.

A lot of HVAC contractors will try and sell you a new pass-through humidifier. They are healthier since they have no reservoir where water can stand and breed bacteria. There is no reason to replace your system as long as it’s working properly and maintained.

Q:

The second floor of my bungalow is very cold in the winter. My plan is to install a couple of those in-the-ductwork fans to force the air upstairs. What’s your opinion or suggestion?

A:

Your plan, while potentially full of hot air, won’t work. More than likely, the attics above and on the sides of those upstairs rooms need insulation. Inadequate insulation will literally suck any heat right out of the rooms as fast or faster than it can warm the rooms.

The insulation in the attics should be a minimum of R-49, which is usually at least 12-18 inches deep. Another thing to check in the attic is any existing ductwork. The ductwork should also be properly and thoroughly insulated so it won’t lose conditioned air through conduction in the attic before it even gets to the rooms.

I’m not done yet. You should also make sure the upstairs rooms or hallway have enough cold air return ductwork. Inadequate cold air returns could be a factor in not enough heat.

The reason I am cold to your idea of in-duct blower booster fans is that they work great for homes with one room far from the furnace that never gets enough heat. The fan is wired into the furnace blower and when the furnace comes on, the 12-volt booster pulls or re-directs a little more heat from the system to the room that really needs it. In your case, it’s the entire second floor, and if you follow my suggestions, you’ll be cool as a cucumber.

Invite your friends and family to join my blog too!

Image

 

 

Advertisements

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s

%d bloggers like this: